The Nynas Nitro Libra Oil Testing as an Isolator on the 150 kV Transformer Using Colour, Water Content, and Breakdown Voltage Testing Method in Bantul Substation

Dimas Septe Ardianta, Ramadoni Syahputra, Muhamad Yusvin Mustar

Abstract


In the system of electricity power, either thermal or electric failure often takes place. In order to prevent such failure, isolator testing towards the power transformer is needed. A mineral oil Nynas Nitro Libra was used as the research subject, in which it was compared to the other oil types, involving new oil, in-use oil, and used crude oil. The method used was testing throughout the colour, water content, and breakdown voltage. Colour testing was conducted by comparing between used oil and typical oil, whereas water content was conducted by mixing chemical ingredients which were Solvent Xylol and toluene, followed by 100°C heating process within 3 hours and condenser cooling down until the moisture dropped down the trap, finished by 6 times breakdown voltage test through environment temperature. The testing result shows that crude oil indicates D 8,0 (black colour), with moisture content TRACE (0,2%) which is 4 ppm. The value of 6-time breakdown voltage test in the temperature of 22°C indicates: 09.4 KV, 09.1 kV, 09.2 kV, 09.6 kV, 09.5 kV, 12.0 kV with dielectric power 3.92 kV/mm.

Keywords


Isolator oil, Colour, Water Content, Breakdown Voltage, Dielectric Strength

Full Text:

PDF

References


[ASTM] American System for Testing Materials. “Standar Test Method for Water in Petroleum Products and Bituminous Materials by Distillation”. United States. Designation: D 95-99. Oktober, 2002.

[ASTM] American System for Testing Materials. “ Standar Test Method for ASTM Color OF Petroleum Products (ASTM Color Scale)”. United States. Designation: D 1500 – 98. 1966.

Arismunandar, Artono. 1997. Teknik Tegangan Tinggi. Jakarta: PT. Pradnya Pramita.

[DPEPULN] Departemen Pertambangan dan Energi Perusahaan Umum Listrik Negara. 1979. Pedoman Pembebanan Transformator Terendam Minyak. Jakarta. SPLN: 17:1979.

[DPEPULN] Departemen Pertambangan dan Energi Perusahaan Umum Listrik Negara. 1987. Standarisasi Peralatan Uji. SPLN: 69- 2:1987.

[DPEPULN] Departemen Pertambangan dan Energi Perusahaan Umum Listrik Negara. 1982 Pedoman Penerapan SpesifikasiPemeliharaan Minyak Isolasi. Jakarta. SPLN: 49-1:1982.

Harlow, J. H. 2004. Electric Power Distribution Handbook. CRC Press : Florida.

Harlow, J. H. 2004. Electric Power Transformator Engineering. CRC Press: Florida.

[IEEE] Institute of Electrical and Electronics Engineers. “Guide For Acceptance and Maintenance of Natural Ester Insulating Liquid in Transformers”. New York. Std. C57,147,2018. Desember 2010.

[IEC] International Eletrotechnichal Commision. “Insulating Liquids – Determination of the Breakdown Voltage at Power Frequency – Test Method”. Geneva. IEC 60156 Ed. 2. July, 1995.

[IEC] International Eletrotecnichal Commision. “Standard Mineral Insulating oila in Electrical Equipment – Supervision and maintenance guidance”. IEC 60422 Ed. 4.0. Januari, 2013.

Jamal, A., Syahputra, R. (2016). Heat Exchanger Control Based on Artificial Intelligence Approach. International Journal of Applied Engineering Research (IJAER), 11(16), pp. 9063-9069.

Jauhari, Rifqi. 2017. Analisa Karakteristik Fisik dan Elektrik Untuk Estimasi Umur Minyak Transformator Menggunakan Hukum Arrhenius. [Tugas Akhir]. Surabaya: Teknologi Industri, Institut Teknologi Sepuluh Nopember.

Nynas Nitro.”Standart Grade Nytro Libra Electrical Insulating Oil”, Ed.4, 2012

[PLN] Perusahaan Listrik Negara. 2014. Buku Pedoman Pemeliharaan Transformer Tenaga. Jakarta: PLN (Persero).

[PLN] Perusahaan Listrik Negara. 2014.Buku Pedoman O & M Trafo Tegangan. Jakarta: PLN (Persero).

Sofyan, Ruslan, dan Efendi. 2018. Studi Penuaan Minyak Transformator Distribusi. Politeknik Negeri Ujung Pandang: Jurnal SNP2M: 63-71.

Stefan, Heryanto. 2014. Analisis Pengujian Minyak Isolasi Pada dan Transformator Tenaga 70KV. Universitas Indonesia: Jurnal Fakultas Teknik Elektro

Supriono. 2014. Buku Ajar Teknik Tegangan Tinggi. Mataram: Universitas Mataram.

Suryadiman, Moh. 2006. Pengujian Tegangan Tembus Minyak Trafo TR 301 Fasilitas Radiometalurgi. BATAN, Vol. 12 No.2. Page 64-112. ISSN: 0852-4777.

Syahputra, R., Robandi, I., Ashari, M. (2015). Performance Improvement of Radial Distribution Network with Distributed Generation Integration Using Extended Particle Swarm Optimization Algorithm. International Review of Electrical Engineering (IREE), 10(2). pp. 293-304.

Syahputra, R., Robandi, I., Ashari, M. (2015). Reconfiguration of Distribution Network with DER Integration Using PSO Algorithm. TELKOMNIKA, 13(3). pp. 759-766.

Syahputra, R., (2012), “Distributed Generation: State of the Arts dalam Penyediaan Energi Listrik”, LP3M UMY, Yogyakarta, 2012.

Syahputra, R., (2016), “Transmisi dan Distribusi Tenaga Listrik”, LP3M UMY, Yogyakarta, 2016.

Syahputra, R., (2015), “Teknologi dan Aplikasi Elektromagnetik”, LP3M UMY, Yogyakarta, 2016.

Syahputra, R., Robandi, I., Ashari, M. (2014). Optimization of Distribution Network Configuration with Integration of Distributed Energy Resources Using Extended Fuzzy Multi-objective Method. International Review of Electrical Engineering (IREE), 9(3), pp. 629-639.

Syahputra, R., Robandi, I., Ashari, M. (2014). Performance Analysis of Wind Turbine as a Distributed Generation Unit in Distribution System. International Journal of Computer Science & Information Technology (IJCSIT), Vol. 6, No. 3, pp. 39-56.

Syahputra, R., (2013), “A Neuro-Fuzzy Approach For the Fault Location Estimation of Unsynchronized Two- Terminal Transmission Lines”, International Journal of Computer Science & Information Technology (IJCSIT), Vol. 5, No. 1, pp. 23-37.

Syahputra, R., (2012), “Fuzzy Multi- Objective Approach for the Improvement of Distribution Network Efficiency by Considering DG”, International Journal of Computer Science & Information Technology (IJCSIT), Vol. 4, No. 2, pp. 57-68.

Syahputra, R., Soesanti, I. (2015). “Control of Synchronous Generator in Wind Power Systems Using Neuro- Fuzzy Approach”, Proceeding of International Conference on Vocational Education and Electrical Engineering (ICVEE) 2015, UNESA Surabaya, pp. 187-193.

Syahputra, R., Robandi, I., Ashari, M. (2014). “Optimal Distribution Network Reconfiguration with Penetration of Distributed Energy Resources”, Proceeding of 2014 1st International Conference on Information Technology, Computer, and Electrical Engineering (ICITACEE) 2014, UNDIP Semarang, pp. 388 - 393.

Syahputra, R., Robandi, I., Ashari, M., (2013), “Distribution Network Efficiency Improvement Based on Fuzzy Multi-objective Method”. International Seminar on Applied Technology, Science and Arts (APTECS). 2013; pp. 224-229.

Syahputra, R., Robandi, I., Ashari, M., (2012), “Reconfiguration of Distribution Network with DG Using Fuzzy Multi-objective Method”, International Conference on Innovation, Management and Technology Research (ICIMTR), May 21-22, 2012, Melacca, Malaysia.

Syahputra, R. (2010). Fault Distance Estimation of Two-Terminal Transmission Lines. Proceedings of International Seminar on Applied Technology, Science, and Arts (2nd APTECS), Surabaya, 21-22 Dec. 2010, pp. 419-423.

Syahputra, R., Soesanti, I. (2015). Power System Stabilizer model based on Fuzzy-PSO for improving power system stability. 2015 International Conference on Advanced Mechatronics, Intelligent Manufacture, and Industrial Automation (ICAMIMIA), Surabaya, 15-17 Oct. 2015 pp. 121 - 126.

Syahputra, R., Soesanti, I. (2016). Power System Stabilizer Model Using Artificial Immune System for Power System Controlling. International Journal of Applied Engineering Research (IJAER), 11(18), pp. 9269- 9278.




DOI: https://doi.org/10.18196/jet.2131

Refbacks

  • There are currently no refbacks.


Copyright (c) 2019 Journal of Electrical Technology UMY

 

Office Address:

Journal of Electrical Technology UMY

Department of Electrical Engineering, Universitas Muhammadiyah Yogyakarta

Jl. Brawijaya, Kasihan, Bantul, Daerah Istimewa Yogyakarta

Phone/Fax: +62274-387656/ +62274-387646,

E-mail: jet@umy.university

Creative Commons License
Journal of Electrical Technology UMY is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.