The Performance of Differential Pressure (DP) and Inlet Temperature by Using Fabric Filter at Coal-Fired Power Station

Rasidah Binti Abdul Rani, Norsa'adah Binti Mahmor, Norazila Binti MD Posdzi, Wan Zaizul Adlan Bin Wan Zulkifli

Abstract


This paper presents the performance of differential pressure (DP) and inlet temperature by using fabric filter at Coal-Fired Power Station. A fabric filter is one of eco-friendly methods that popular application in the industry to cater and filter the flue gas that contained fly ashes, that been produced by combustion of pulverized coal inside the boiler furnace. This study focuses on analyse the reading of differential pressure and inlet temperature and determining condition of fabric filter. The evaluation of this result is to maintain the differential pressure at 14 – 18 mbar and inlet temperature at 130 0C. The performance of the fabric filter will be analysed using the monitoring report performance based on daily walkdown inspection and calibration schedule report. Based on the report results prove that the performance of fabric filter is in satisfactory condition and met with DOE requirements, which the flue gas within in 30 minutes observation only contain 150mg/m3 of ash. The protection of the system ensures the fabric filter in optimum condition. 

Keywords


Differential pressure, Inlet temperature, Fabric Filter

Full Text:

PDF

References


Adlan, w. z. (2018). Bag Filter Operation. Certified Environmental Professional In Bag Filter Operation (CePBFO).

B.O. Andersena, N. N. (2015). Numerical and experimental study of pulse-jet cleaning. Powder Technolog.

Cheng-hang Zheng, L. W.-x.-g.-t.-s. (2018). Co-benefit of hazardous trace elements capture in dust removal devices of ultra-low emission coal-fired power plants. Journal of Zhejiang University-SCIENCE A.

E.RomeroXingchaoWang, C. (2019). Chapter Three - Key technologies for ultra-low emissions from coal-fired power plants. In Advances in Ultra-Low Emission Control Technologies for Coal-Fired Power Plants (pp. 39-79). Energy Research Center, Lehigh University, Bethlehem, PA, United States: Woodhead Publishing Series in Energy.

Enviromental Quality (Clean Air) Regulation 2014. Warta Kerajaan Persekutuan, Jabatan Peguam Negara.

Jagtap, D. C. (n.d.). (2018) Pollution Controller-Fabric Filter. International Research Journal of Engineering and Technology. www.irjet.net

Jin SikKim, M.-H. (2019). Measurement of effective filtration area of pleated bag filter for pulse-jet cleaning. Powder Technology, volume 343, 662-670.

KazukiFurumoto, T.-P.-N. (2021). Influence of pulse-jet cleaning interval on performance of compact dust collector with pleated filter. Separation and Purification Technology, volume 279.

Kenneth M. Cushing, R. L. (2012). Operating History and Current Status of Fabric Filters in the Utility Industry. Journal of the Air & Waste Management Association , 1051-1058.

Ouyang, T. X. ( 2021). A novel Design of low-grade waste heat utilization for coal-fired power plants with sulfuric acid recovery. Energy Conversion and Management, volume 227.

R.Haridass. (2017). Performance Improvement Of Pollution Controldevice Used In Small Scale Foundry Industry. International Journal of Research In Science & Engineering, Volume: 3.

ShuruiSunab, W. (2021). Effects of air pollution control devices on volatile organic compounds reduction in coal-fired power plants. Science of The Total Environment, volume 782.

Smith, R. C. (2012). Fabric Filter Technology for Utility Coal-Fired Part III: Performance of Full-Scale Utility Baghouses. Journal of the Air Pollution Control Association.

Tomonori Fukasawa, C. K. (2022). Effects of surface finish of nonwoven fabric bag filter on filter efficiency. Chemical Engineering Technology, volume 45, issue 1.

Victor h. belba, w. t. (2012). The Potential of Pulse-Jet Baghouses for Utility Boilers. Part 1: A Worldwide Survey of Users. Journal of the Air & Waste Management Association , 209-217.

Xie, B. L. (2018). Analysis of the performance of a novel dust. Powder Technology 339, 695-701.

XiuweiMa, Y. H. (2021). Adsorption behaviors of VOCs under coal-combustion flue gas environment using activated carbon injection coupled with bag filtering system. Colloids and Surfaces A: Physicochemical and Engineering Aspects, Volume 627.




DOI: https://doi.org/10.18196/jmpm.v7i1.18382

Refbacks

  • There are currently no refbacks.


 

Editorial Office :

JMPM (Jurnal Material dan Proses Manufaktur)

Department of Mechanical Engineering, Faculty of Engineering, Universitas Muhammadiyah Yogyakarta.

Jl. Brawijaya Tamantirto Kasihan Bantul 55183 Indonesia

Email: jmpm@umy.ac.id

Telp/Fax: (62)274-387656    

Whatsapp: 085642095827