Robust Adaptive Trajectory Tracking Sliding Mode Control for Industrial Robot Manipulator using Fuzzy Neural Network

Quynh Nguyen Xuan, Cuong Nguyen Cong, Nghien Nguyen Ba

Abstract


This paper presents a control method for a two-link industrial robot manipulator system that uses Fuzzy Neural Networks (FNNs) based on Sliding Mode Control (SMC) to investigate joint position control for periodic motion and predefined trajectory tracking control. The proposed control scheme addresses the challenges of designing a suitable control system that can achieve the required approximation errors while ensuring the stability and robustness of the control system in the face of joint friction forces, parameter variations, and external disturbances. The control scheme uses four layers of FNNs to approximate nonlinear robot dynamics and remove chattering control efforts in the SMC system. The adaptive turning algorithms of network parameters are derived using a projection algorithm and the Lyapunov stability theorem. The proposed control scheme guarantees global stability and robustness of the control system, and position is proven. Simulation and experiment results from a two-link IRM in an electric power substation are presented in comparison to PID and AF control to demonstrate the superior tracking precision and robustness of the proposed intelligent control scheme.

Keywords


Robot Manipulators; Fuzzy Neural Network; Sliding Mode Control; Robust Adaptive Control.

Full Text:

PDF

References


S. Jung, “Sliding Mode Control for a Hybrid Force Control Scheme of a Robot Manipulator Under Uncertain Dynamics,” Int. J. Control Autom. Syst., vol. 21, pp. 1634–1643, 2023.

J. Liang et al., “Robust Observer-based Trajectory Tracking Control for Unmanned Aerial Manipulator,” Int. J. Control Autom. Syst., vol. 21, pp. 616–629, 2023.

Z. Huang and C. Sun, “Adaptive Global Robust Tracking Control for Uncertain Dynamic Systems,” Int. J. Control Autom. Syst., vol. 21, pp. 1070–1079, 2023.

G. Bhardwaj, N. Sukavanam, and B. Raman, “Fast Terminal Discrete-time Sliding Mode Control with Fuzzy-based Impedance Modulation for Toe Foot Bipedal Robot Going Upstairs,” Int. J. Control Autom. Syst., vol. 21, pp.1659–1669, 2023.

J. Chen et al., “Low Chattering Trajectory Tracking Control of Non-singular Fast Terminal Sliding Mode Based on Disturbance Observer,” Int. J. Control Autom. Syst., vol. 21, pp. 440–451, 2023.

T. C. Kargin and J. A. Kołota, “Reinforcement Learning Approach for Continuum Robot Control,” J. Intell. Robot Syst., vol. 109, no. 77, 2023.

G. V. Hollweg et al., “A Modified Robust Adaptive Super-twisting Sliding Mode Controller for Grid-connected Converters,” Int. J. Control Autom. Syst., vol. 21, pp. 3151–3165, 2023.

D. G. Jiang et al., “Nonsingular Fast Terminal Sliding Mode Control for Uncertain Nonlinear Systems Based on Adaptive Super-twisting Sliding Mode Disturbance Observer,” Int. J. Control Autom. Syst., vol. 21, pp. 3210–3223, 2023.

A. Gholami, J. Q. Sun, and R. Ehsani, “Neural Networks Based Optimal Tracking Control of a Delta Robot With Unknown Dynamics,” Int. J. Control Autom. Syst., vol. 21, pp. 3382–3390, 2023.

J. Narayan et al., “Adaptive RBF neural network-computed torque control for a pediatric gait exoskeleton system: an experimental study,” Intel. Serv. Robotics, vol. 16, pp. 549–564, 2023.

X. Zhao, Z. Liu, B. Jiang, and C. Gao, "Switched Controller Design for Robotic Manipulator via Neural Network-Based Sliding Mode Approach," in IEEE Transactions on Circuits and Systems II: Express Briefs, vol. 70, no. 2, pp. 561-565, Feb. 2023.

B. Brahmi et al., “Adaptive high-order sliding mode control based on quasi-time delay estimation for uncertain robot manipulator,” Control Theory Technol., vol. 18, pp. 279–292, 2020.

Z. Li et al., “Improved sliding mode control for mobile manipulators based on an adaptive neural network,” J. Mech. Sci. Technol., vol. 37, pp. 2569–2580, 2023.

X. Li et al., “A Novel Adaptive Sliding Mode Control of Robot Manipulator Based on RBF Neural Network and Exponential Convergence Observer,” Neural Process Lett., vol. 55, pp.10037–10052, 2023.

L. Bao et al., “Design of a Sliding Mode Controller with Fuzzy Rules for a 4-DoF Service Robot,” Int. J. Control Autom. Syst., vol. 19, pp. 2869–2881, 2021.

Z. Xu et al., “Backstepping Sliding Mode Control Based on Extended State Observer for Robotic Manipulators with LuGre Friction,” Int. J. Control Autom. Syst., vol. 20, pp.2054–2066, 2022.

X. Chen et al., “Adaptive Control Design and Fractional Differential Inequality Approach to Complete Synchronization Analysis on Caputo Delayed Quaternion-valued Network Systems,” Int. J. Control Autom. Syst., vol. 21, pp. 3274–3284, 2023.

T. Zhao, P. Qin, S. Dian, and B. Guo, “Fractional order sliding mode control for an omni-directional mobile robot based on self-organizing interval type-2 fuzzy neural network,” Information Sciences, vol. 654, pp. 119819, 2024.

M. Afaq, A. Jebelli, and R. Ahmad, “An Intelligent Thermal Management Fuzzy Logic Control System Design and Analysis Using ANSYS Fluent for a Mobile Robotic Platform in Extreme Weather Applications,” J. Intell. Robot Syst., vol. 107, no. 11, 2023.

Q. Liu et al., “Adaptive Fuzzy Finite Time Prescribed Performance Control for Long Stroke Hybrid Robots,” Int. J. Control Autom. Syst., vol. 21, pp. 3116–3126, 2023.

A. K. Kashyap and D. R. Parhi, “Modified type-2 fuzzy controller for intercollision avoidance of single and multi-humanoid robots in complex terrains,” Intel Serv Robotics, vol. 16, pp. 87–108, 2023.

F. C. Sun, Z. Q. Sun, and G. Feng, “An adaptive fuzzy controller based on sliding mode for robot manipulators,” Systems, Man, and Cybernetics, Part B: Cybernetics, IEEE Transactions on, vol. 29, no. 5, pp. 661-667, 1999.

X. Zhiyu, F. Gang, and T. Hesketh, “Piecewise Integral Sliding-Mode Control for T-S Fuzzy Systems,” IEEE Transactions on, vol. 19, no. 1, pp 65-74, 2010.

K. Zheng, Q. Zhang, L. Peng, and S. Shuisheng, “Adaptive memetic differential evolution-back propagation-fuzzy neural network algorithm for robot control,” Information Sciences, vol. 637, pp. 118940, 2023.

X. Gao, H. Yu, Q. Yang, X. Meng, and P. Zhang, “Neural network based dynamic surface integral nonsingular fast terminal sliding mode control for manipulators with disturbance rejection,” Journal of the Franklin Institute, vol. 360, no.15, pp. 11032-11054, 2003.

X. Yin, L. Pan, and S. Cai, “Robust adaptive fuzzy sliding mode trajectory tracking control for serial robotic manipulators,” Robotics and Computer-Integrated Manufacturing, vol. 72, pp 101884, 2021.

L. Peng and W. Peng-Yung, “Neural-fuzzy control system for robotic manipulators,” IEEE Control Systems Magazine, vol. 22, no. 1, pp. 53-63, 2002.

E. Meng Joo and G. Yang, “Robust adaptive control of robot manipulators using generalized fuzzy neural networks,” IEEE Transactions on Industrial Electronics, vol, 50, no. 3, pp. 620-628, 2003.

J. Huang et al., “Vehicle Platoon Tracking Control Based on Adaptive Neural Network Algorithm,” Int. J. Control Autom. Syst., vol. 21, pp. 3405–3418, 2023.

W. Paszkowiak, M. Pelic, and T. Bartkowiak, “A Neural-network-based Control System for a Dynamic Model of Tractor With Multiple Trailers System,” Int. J. Control Autom. Syst., vol. 21, pp. 3456–3469, 2023.

M. Benrabah et al., “Adaptive Fourier Series Neural Network PID Controller,” Int. J. Control Autom. Syst., vol. 19, pp. 3388–3399, 2021.

Q. Wen et al., “Disturbance Observer-based Neural Network Integral Sliding Mode Control for a Constrained Flexible Joint Robotic Manipulator,” Int. J. Control Autom. Syst., vol. 21, pp. 1243–1257, 2023.

Z. Zhang et al., “A Behavior-based Adaptive Dynamic Programming Method for Multiple Mobile Manipulators Coordination Control,” Int. J. Control Autom. Syst. vol. 21, pp.3022–3035, 2023.

X. Guan et al., “Finite-time Sliding Mode Fault-tolerant Control for Networked Control Systems With Intermittent Fault Under Event-triggered Scheme,” Int. J. Control Autom. Syst., vol. 21, pp. 3259–3273, 2023.

J. Hu, D. Zhang, Z. Guang Wu, and H. Li, “Neural network-based adaptive second-order sliding mode control for uncertain manipulator systems with input saturation,” ISA Transactions, vol.136, pp 126-138, 2023.

Z. Zhang, L. Zheng, Z. Chen, L. Kong, and H. R. Karimi, “Mutual – Collision – Avoidance Scheme Synthesized by Neural Networks for Dual Redundant Robot Manipulators Executing Cooperative Tasks,” IEEE Transactions on on Neural Networks and Learning Systems, vol. 32, no. 3, pp. 1052-1066, 2021.

Z. Li andS. Li, “Neural Network Model-Based Control for Manipulator,” IEEE Transactions on Neural Networks and Learning Systems, vol. 34, no. 6, pp. 2854-2868, 2023.

V. Narayanan, S. Jagannathan, and K. Ramkumar, “Event Sampled Feedback Output Control of Robot Manipulators Using Neural Networks,” IEEE Transactions on Neural Networks and Learning Systems, vol. 30, no. 6, pp. 1651-1658, 2019.

X. Li, Z. Xu, S. Li, H. Wu, and X. Zhou, “Cooperative Kinematic Control for Multiple Redundant Manipulators Under Partially Known Information Using Recurrent Neural Network,” IEEE Access, vol. 8, pp. 40029-40038, 2020.

J. I. Mulero-Martinez, “Robust GRBF Static Neurocontroller With Switch Logic for Control of Robot Manipulators,” IEEE Transactions on Neural Networks and Learning Systems, vol. 23, no. 7, pp 1053-1064, 2012.

L. Min-Jung and C. Young-Kiu, “An adaptive neurocontroller using RBFN for robot manipulators,” IEEE Transactions on Industrial Electronics, vol. 51, no. 3, pp. 711-717, 2004.

F. M. Caswara and H. Unbehauen, “A neurofuzzy approach to the control of a flexible-link manipulator,” IEEE Transactions on Robotics and Automation, vol. 18, no. 6, pp. 932-944, 2002.

G. Yang, E. Meng Joo, and Y. Song, “Adaptive control of robot manipulators using fuzzy neural networks,” IEEE Transactions on Industrial Electronics, vol. 48, no. 6, pp. 1274-1278, 2001.

C. Jiang et al., “Adaptive NN Output Feedback Control of Electro-hydraulic System,” Int. J. Control Autom. Syst., vol. 21, pp. 2739–2747, 2023.

Z. Lu, Y. Li, and Y. Li, “A Novel Decentralized Fixed-time Tracking Control for Modular Robot Manipulators,” Theoretical and Experimental Verification. Int. J. Control Autom. Syst., vol. 21, pp 3036–3047, 2023.

Y. Jiang, Y. Wang, Z. Miao, J. Na, Z. Zhao, and C. Yang, “Composite-Learning-Based Adaptive Neural Control for Dual-Arm Robots With Relative Motion,” IEEE Transactions on Neural Networks and Learning Systems, vol, 33, no. 3, pp. 1010-1021, 2022.

H. Li and W. Chou, “Adaptive FNN Backstepping Control for Nonlinear Bilateral Teleoperation With Asymmetric Time Delays and Uncertainties,” Int. J. Control Autom. Syst., vol. 21, pp. 3091–3104, 2023.

W. He, Z. Yan, Y. Sun, Y. Ou, and C. Sun, “Neural-Learning-Based Control for a Constrained Robotic Manipulator With Flexible Joints,” IEEE Transactions on Neural Networks and Learning Systems, vol. 29, no.12, pp. 5993-6003, 2018.

D. Chen, S. Li, and Q. Wu, “A Novel Supertwisting Zeroing Neural Network With Application to Mobile Robot Manipulators,” in IEEE Transactions on Neural Networks and Learning Systems, vol. 32, no. 4, pp. 1776-1787, 2021.

S. Zhang, Y. Wu, X. He, and J. Wang, “Neural Network-Based Cooperative Trajectory Tracking Control for a Mobile Dual Flexible Manipulator,” IEEE Transactions on Neural Networks and Learning Systems, vol. 34, no. 9, 2023.

H. Huang, C. Yang, C. L. Philip Chen, “Optimal Robot–Environment Interaction Under Broad Fuzzy Neural Adaptive Control,” IEEE Transactions on Cybernetics, vol. 51, no. 7, pp. 3824-3835, 2021.

J. Guo, H. T. Nguyen, C. Liu, and C. C. Cheah, “Convolutional Neural Network-Based Robot Control for an Eye-in-Hand Camera, IEEE Transactions on Systems, Man, and Cybernetics: Systems, vol. 53, no. 8, pp. 4764-4775, 2023.

Y. Fan, W. Jing, and F. Bernelli-Zazzera, “Nonlinear Tracking Differentiator Based Prescribed Performance Control for Space Manipulator,” Int. J. Control Autom. Syst., vol. 21, pp. 876–889, 2023.

L. Teng, M. A. Gull, and S. Bai, "PD-Based Fuzzy Sliding Mode Control of a Wheelchair Exoskeleton Robot," in IEEE/ASME Transactions on Mechatronics, vol. 25, no. 5, pp. 2546-2555, Oct. 2020.

M. H. Barhaghtalab, M. A. Sepestanaki, S. Mobayen, B. Jalilvand, A. Fekih, and V. Meigoli, “Design of an adaptive fuzzy-neural inference system-based control approach for robotic manipulators,” Applied Soft Computing, vol 149, pp. 110970, 2023.

F. Xie, G. Liang, and Y. R. Chien, “Highly Robust Adaptive Sliding Mode Trajectory Tracking Control of Autonomous Vehicles,” Sensors, vol. 23, no. 7, 2023.

L. Zheng and Z. Zhang, “Time-Varying Quadratic-Programming-Based Error Redefinition Neural Network Control and Its Application to Mobile Redundant Manipulators,” IEEE Transactions on Automatic Control, vol. 67, no. 11, pp. 6151-6158, 2022.

D. Huang, C. Yang, Y. Pan, and L. Cheng, “Composite Learning Enhanced Neural Control for Robot Manipulator With Output Error Constraints,” IEEE Transactions on Industrial Informatics, vol. 17, no. 1, pp. 209 - 218, 2021.

H. Wang et al., “Design and locomotion analysis of an arm-wheel-track multimodal mobile robot,” Intel. Serv. Robotics, vol. 16, pp. 485–495, 2023.

I. Rhee et al., “Hybrid impedance and admittance control of robot manipulator with unknown environment,” Intel. Serv. Robotics, vol. 16, pp. 49–60, 2023.

T. An, Y. Wang, G. Liu, Y. Li, and B. Dong, “Cooperative Game-Based Approximate Optimal Control of Modular Robot Manipulators for Human–Robot Collaboration,” IEEE Transactions on Cybernetics, vol. 53, no,7, pp. 4691-470, 2023.

H. Sai et al., “Chattering-free Fast Fixed-time Sliding Mode Control for Uncertain Robotic Manipulators,” Int. J. Control Autom. Syst., vol. 21, pp. 630–644, 2023.

C. Yang, G. Peng, L. Cheng, J. Na, and Z. Li, “Force Sensorless Admittance Control for Teleoperation of Uncertain Robot Manipulator Using Neural Networks,” IEEE Transactions on Systems, Man, and Cybernetics: Systems, vol. 51, no. 5, pp. 1-11, 2021.

L. Ding et al., “Adaptive Robust Control via a Nonlinear Disturbance Observer for Cable-driven Aerial Manipulators,” Int. J. Control Autom. Syst., vol. 21, pp. 604–615, 2023.

Z. Xu, S. Li, X. Zhou, S. Zhou, T. Cheng, and Y. Guan, “Dynamic Neural Networks for Motion-Force Control of Redundant Manipulators: An Optimization Perspective,” IEEE Transactions on Industrial Electronics, vol. 34, no.8, pp. 1-11, 2023.

Y. Wang, H. Yang, and W. Deng, “A New Practical Robust Adaptive Control of Cable-driven Robots,” Int. J. Control Autom. Syst., vol. 21, pp. 2685–2697, 2023.

C. Zhu, Y. Jiang, and C. Yang, “Fixed-Time Neural Control of Robot Manipulator With Global Stability and Guaranteed Transient Performance,” IEEE Transactions on Industrial Electronics, vol.70, no.1, pp. 803-812, 2023.

Y. Li, L. Wang, K. Liu, W. He, Y. Yin, and R. Johansson, “Distributed Neural-Network-Based Cooperation Control for Teleoperation of Multiple Mobile Manipulators Under Round-Robin Protocol,” IEEE Transactions on Neural Networks and Learning Systems, vol. 34, no.8, pp. 4841-4855, 2023.

F. J. Lin, P. H. Shen, S. P. Hsu, “Adaptive backstepping sliding mode control for linear induction motor drive,” IEEE Proceedings Electric Power Applications, vol. 149, no. 3, pp. 184-194, 2002.

S. A. Wadoo, “Sliding Mode Control of Crowd Dynamics,” IEEE Transactions on Control Systems Technology, vol. 21, no. 3, pp. 1008-1015, 3013.

Q. Zhang and A. Benveniste, “Wavelet networks,” IEEE Transactions on Neural Networks, vol. 3, no. 6, pp. 889-898, 1992.

Y. Su, "Comments on “A New Adaptive Sliding-Mode Control Scheme for Application to Robot Manipulators”," in IEEE Transactions on Industrial Electronics, vol. 67, no. 8, pp. 7116-7120, Aug. 2020.

T. N. Truong, A. T. Vo, and H. -J. Kang, "A Backstepping Global Fast Terminal Sliding Mode Control for Trajectory Tracking Control of Industrial Robotic Manipulators," in IEEE Access, vol. 9, pp. 31921-31931, 2021.

R. -D. Xi, X. Xiao, T. -N. Ma, and Z. -X. Yang, "Adaptive Sliding Mode Disturbance Observer Based Robust Control for Robot Manipulators Towards Assembly Assistance," in IEEE Robotics and Automation Letters, vol. 7, no. 3, pp. 6139-6146, July 2022.

J. Choi, J. Baek, W. Lee, Y. S. Lee, and S. Han, "Adaptive Model-Free Control With Nonsingular Terminal Sliding-Mode for Application to Robot Manipulators," in IEEE Access, vol. 8, pp. 169897-169907, 2020.

F. L. Lewis, C. T. Abdallah, D. M. Dowson. Control of Robot Manipulators. New York:Macmillan, 1993.

S. Shun-Feng, L. Zne-Jung, and W. Yan-Ping, “Robust and fast learning for fuzzy cerebellar model articulation controllers,” IEEE Transactions on Systems, Man, and Cybernetics, Part B: Cybernetics, vol. 36, no. 1, pp. 203-208, 2006.

X. Sun, L. Zhang, and J. Gu, “Neural-network based adaptive sliding mode control for Takagi-Sugeno fuzzy systems,” Information Sciences, vol 628, pp. 240-253, 2023.

S. Ahmed, A. T. Azar, and I. A. Hameed, “ Fractional-order Fixed-time Non-singular Sliding Mode Control for Nonlinear Robotic Manipulators,” IFAC-PapersOnLine, vol 56, no.2, pp. 8105-8110, 2023.

D. Guo, J. Liu, S. Zheng, J.-P. Cai, and P. Jiang, “Singularity-Free Fixed-Time Neuro-Adaptive Control for Robot Manipulators in the Presence of Input Saturation and External Disturbances,” in IEEE Access, vol 12, pp. 1794-1804, 2024.

D. Feller, “Kinematics of a Novel Serial-Parallel, Compliant, Three-Legged Robot,” in IEEE Access, vol 12, pp. 1794-1804, 2024.

N. Gafur, G. Kanagalingam, A. Wagner, and M. Ruskowski, “Dynamic Collision and Deadlock Avoidance for Multiple Robotic Manipulators,” in IEEE Access, vol 10, pp. 55766-55781, 2022.

H.-L. Huang, M.-Y. Cheng, and T.-Y. Huang, “A Rapid Base Parameter Physical Feasibility Test Algorithm for Industrial Robot Manipulator Identification Using a Recurrent Neural Network,” in IEEE Access, vol 1, pp. 1-13, 2023.




DOI: https://doi.org/10.18196/jrc.v5i2.20722

Refbacks

  • There are currently no refbacks.


Copyright (c) 2024 Quynh Nguyen Xuan, Cuong Nguyen Cong

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

 

Journal of Robotics and Control (JRC)

P-ISSN: 2715-5056 || E-ISSN: 2715-5072
Organized by Peneliti Teknologi Teknik Indonesia
Published by Universitas Muhammadiyah Yogyakarta in collaboration with Peneliti Teknologi Teknik Indonesia, Indonesia and the Department of Electrical Engineering
Website: http://journal.umy.ac.id/index.php/jrc
Email: jrcofumy@gmail.com

Kuliah Teknik Elektro Terbaik