Bio-Inspired Robotics: Kinematic and Gait Analysis of Quad and Hexa-Legged Systems
DOI:
https://doi.org/10.18196/jrc.v6i2.23905Keywords:
Bio-Inspired Robot, Forward and Reverse Kinematics, Hexa Leg Robot, Limb Kinematics, Quad Leg Robot, Spider-Mimicking RobotAbstract
Navigating hazardous environments, such as areas with fire risks, wild animal activity, or inaccessible terrains, poses significant challenges, necessitating the development of bio-inspired robotic systems. This study focuses on the biomechanical design and kinematic analysis of a spider-mimicking robot, specifically examining quad and hexa-legged configurations to optimize movement efficiency and stability. The research employed 3D Computer-Aided Design (CAD) in Fusion 360 to model and simulate the robot's leg framework, analyzing deformation, tension, and strain. Fused Deposition Modelling (FDM) with Poly Lactic Acid (PLA) material was used for component fabrication, chosen for its balance of lightweight properties and structural integrity, validated through stress analysis. A single limb’s forward and reverse kinematics were studied, enabling the development of optimized gait patterns. SIMSCAPE Multibody in MATLAB was utilized for dynamic simulations, and Proportional Derivative (PD) and Proportional Integral Derivative (PID) controllers were tested to evaluate trajectory tracking accuracy and stability. Results show that the six-legged configuration exhibits superior stability with a 15% improvement in gait cycle efficiency and a 20% reduction in energy consumption per stride compared to the four-legged counterpart. The use of PID controllers further enhanced performance, achieving a 12% improvement in settling time and reducing oscillations in trajectory tracking tasks. The choice of PLA material ensured durability under operational loads, with minimal deformation over repeated stress cycles. Servomotor selection and configuration were tailored to optimize torque and speed, enabling precise leg control. This study highlights the potential of bio-inspired robots to advance robotic mobility through optimized kinematics and material choices.
References
C. Sun, M. Yuan, F. Li, Z. Yang, and X. Ding, "Design and simulation analysis of hexapod bionic spider robot," in Journal of Physics: Conference Series, vol. 1168, no. 2, p. 022094, 2019.
R. D. Shi, X. L. Zhang, and Y. A. Yao, "A CPG-based control method for the multi-mode locomotion of a desert spider robot," Robot, vol. 40, no. 2, pp. 146-157, 2018.
Y. Zhang, Y. Qian, Y. Ding, B. Hou, and R. Wang, "Adaptive walking control for quadruped robot by using oscillation patterns," Scientific Reports, vol. 13, no. 1, p. 19756, 2023.
V. V. Kravchenko et al., "Comparison of Spider-Robot Information Models," Journal of Robotics and Control (JRC), vol. 4, no. 5, pp. 719-725, 2023.
Y. Zhang, G. Qiao, Q. Wan, L. Tian, and D. Liu, "A novel double-layered central pattern generator-based motion controller for the hexapod robot," Mathematics, vol. 11, no. 3, p. 617, 2023.
A. H. Abdulwahab, A. Z. A. Mazlan, A. F. Hawary, and N. H. Hadi, "Quadruped robots mechanism, structural design, energy, gait, stability, and actuators: a review study," International Journal of Mechanical Engineering and Robotics Research, vol. 12, no. 6, 2023.
Z. Tang, P. Qi, and J. Dai, "Mechanism design of a biomimetic quadruped robot," Industrial Robot: An International Journal, vol. 44, no. 4, pp. 512-520, 2017.
R. Vidoni and A. Gasparetto, "Efficient force distribution and leg posture for a bio-inspired spider robot," Robotics and Autonomous Systems, vol. 59, no. 2, pp. 142-150, 2011.
E. Z. Moore. Leg Design and Stair Climbing Control for the RHex Robotic Hexapod. Department of Mechanical Engineering McGill University, 2002.
B. Gassmann, K. -U. Scholl, and K. Berns, "Locomotion of LAURON III in rough terrain," 2001 IEEE/ASME International Conference on Advanced Intelligent Mechatronics. Proceedings (Cat. No.01TH8556), vol. 2, pp. 959-964, 2001, doi: 10.1109/AIM.2001.936810.
E. Burkus and P. Odry, "Autonomous Hexapod Walker Robot "Szabad(ka)"," 2007 5th International Symposium on Intelligent Systems and Informatics, pp. 103-106, 2007, doi: 10.1109/SISY.2007.4342633.
R. Shi, X. Zhang, Y. Tian, S. Dong, and Y. Yao, "A CPG-based control method for the rolling locomotion of a desert spider," 2016 IEEE Workshop on Advanced Robotics and its Social Impacts (ARSO), pp. 243-248, 2016, doi: 10.1109/ARSO.2016.7736289.
F. Asadi, M. Khorram, and S. A. A. Moosavian, "CPG-based gait transition of a quadruped robot," 2015 3rd RSI International Conference on Robotics and Mechatronics (ICROM), pp. 210-215, 2015, doi: 10.1109/ICRoM.2015.7367786.
H. Yu, H. Gao, L. Ding, M. Li, Z. Deng, and G. Liu, "Gait Generation With Smooth Transition Using CPG-Based Locomotion Control for Hexapod Walking Robot," in IEEE Transactions on Industrial Electronics, vol. 63, no. 9, pp. 5488-5500, Sept. 2016, doi: 10.1109/TIE.2016.2569489.
Y. Zhang and T. Yasuno, "Adaptive walking control for quadruped robot on irregular terrain based on CPG network," Journal of signal processing, vol. 15, no. 4, pp. 315-318, 2011.
Y. She, C. Li, J. Cleary, and H.-J. Su, "Design and fabrication of a soft robotic hand with embedded actuators and sensors," Journal of Mechanisms and Robotics, vol. 7, no. 2, p. 021007, 2015.
M. Z. A. Rashid, M. S. M. Aras, A. A. Radzak, A. M. Kassim, and A. Jamali, "Development of hexapod robot with manoeuvrable wheel," International Journal of Advanced Science and Technology, vol. 49, 2012.
P. Biswal and P. K. Mohanty, "Development of quadruped walking robots: A review," Ain Shams Engineering Journal, vol. 12, no. 2, pp. 2017-2031, 2021.
K. Hauser, T. Bretl, J.-C. Latombe, K. Harada, and B. Wilcox, "Motion planning for legged robots on varied terrain," The International Journal of Robotics Research, vol. 27, no. 11-12, pp. 1325-1349, 2008.
I. M. Salleh, M. N. Muhtazaruddin, S. Sarip, M. Z. Hassan, and M. Y. M. Daud, "Structural health monitoring (SHM) on high stress loading of wing bracket," Journal of Advanced Research in Applied Mechanics, vol. 27, no. 1, pp. 16-22, 2016.
C. Urrea, L. Valenzuela, and J. Kern, "Design, Simulation, and Control of a Hexapod Robot in Simscape Multibody," Applications from Engineering with MATLAB Concepts, pp. 126-137, 2016.
K. Nithish, S. Amanullah, K. Akash, and H. Prasaath SP, "Spider Bot--A Quadruped Robot for Data Gathering," Journal of Engineering Science & Technology Review, vol. 15, no. 6, 2022.
Q. Shi et al., "Development of a Small-Sized Quadruped Robotic Rat Capable of Multimodal Motions," in IEEE Transactions on Robotics, vol. 38, no. 5, pp. 3027-3043, Oct. 2022, doi: 10.1109/TRO.2022.3159188.
L. Wang et al., "Design and implementation of symmetric legged robot for highly dynamic jumping and impact mitigation," Sensors, vol. 21, no. 20, p. 6885, 2021.
B. Katz, J. D. Carlo and S. Kim, "Mini Cheetah: A Platform for Pushing the Limits of Dynamic Quadruped Control," 2019 International Conference on Robotics and Automation (ICRA), pp. 6295-6301, 2019, doi: 10.1109/ICRA.2019.8793865.
G. Zhang, S. Ma, J. Liu, X. Zeng, L. Kong, and Y. Li, "Q‐Whex: A simple and highly mobile quasi‐wheeled hexapod robot," Journal of field robotics, vol. 40, no. 6, pp. 1444-1459, 2023.
M. Travers, A. Ansari, and H. Choset, "A dynamical systems approach to obstacle navigation for a series-elastic hexapod robot," 2016 IEEE 55th Conference on Decision and Control (CDC), pp. 5152-5157, 2016, doi: 10.1109/CDC.2016.7799057.
K. U. Ariawan, G. S. Santyadiputra, and I. W. Sutaya, "Design of Hexapod Robot Movement Based on Arduino Mega 2560," In Journal of Physics: Conference Series, vol. 1165, no. 1, p. 012011, 2019.
S. Rathnaprabha, S. Nivetha, S. Pradeepa, and S. Sindhu, "Designing of Hexapod Robot," International Journal of Advanced Research in Electrical, Electronics and Instrumentation Engineering, vol. 5, no. 2, 2016.
M. Nitulescu, M. Ivanescu, V. D. Hai Nguyen, and S. Manoiu-Olaru, "Designing the legs of a hexapod robot," 2016 20th International Conference on System Theory, Control and Computing (ICSTCC), pp. 119-124, 2016, doi: 10.1109/ICSTCC.2016.7790651.
M. M. Billah, M. Ahmed, and S. Farhana, “Walking hexapod robot in disaster recovery: developing algorithm for terrain negotiation and navigation,” in Proceedings of world academy of science, engineering and technology, vol. 42, pp. 328-333, 2008.
M. Kurisu, "A study on teleoperation system for a hexapod robot — Development of a prototype platform," 2011 IEEE International Conference on Mechatronics and Automation, pp. 135-141, 2011, doi: 10.1109/ICMA.2011.5985645.
A, K. Mishra. Design, simulation, fabrication and planning of bio-inspired quadruped robot. Requirement of the degree of Master of Technology, Indian Institute of Technology Patna: Bihar, India, 2014.
D. Huang, W. Fan, Y. Liu, and T. Liu, "Design of a Humanoid Bipedal Robot Based on Kinematics and Dynamics Analysis of Human Lower Limbs," 2020 IEEE/ASME International Conference on Advanced Intelligent Mechatronics (AIM), pp. 759-764, 2020, doi: 10.1109/AIM43001.2020.9158973.
L. Wang et al., "Design and dynamic locomotion control of quadruped robot with perception-less terrain adaptation," Cyborg and Bionic Systems, 2022.
R. Barrio, Á. Lozano, M. A. Martínez, M. Rodríguez, and S. Serrano, "Routes to tripod gait movement in hexapods," Neurocomputing, vol. 461, pp. 679-695, 2021.
S. A. M. Esa and N. A. C. Sidik, "Design and Analysis of Vortex Induced Vibration Suppression Device," Journal of Advanced Research Design, vol. 85, no. 1, pp. 1-10, 2021.
N. F. C. Halim and N. A. C. Sidik, "Nanorefrigerants: A Review on Thermophysical Properties and Their Heat Transfer Performance," Journal of Advanced Research in Applied Sciences and Engineering Technology, vol. 20, no. 1, pp. 42-50, 2020.
C. Chun, T. Biswas, and V. Bhandawat, "Drosophila uses a tripod gait across all walking speeds, and the geometry of the tripod is important for speed control," Elife, vol. 10, p. e65878, 2021.
Q. Xi, Z. Chen, K. Yin, X. Liu, and F. Gao, “Fault-tolerant gait for Hexapod Robots with partial active joints locked,” Mechanism and Machine Theory, vol. 205, p. 105895, 2025.
D. Grzelczyk, B. Stanczyk, and J. Awrejcewicz, "Kinematics, dynamics and power consumption analysis of the hexapod robot during walking with tripod gait," International Journal of Structural Stability and Dynamics, vol. 17, no. 5, p. 1740010, 2017.
Y. Zheng, K. Xu, Y. Tian, and X. Ding, "Different manipulation mode analysis of a radial symmetrical hexapod robot with leg—arm integration," Frontiers of Mechanical Engineering, vol. 17, no. 1, p. 8, 2022.
J. Gu, L. Li, S. Zhou, and W. Zhang, "Research on foot trajectory planning of quadruped robot: based on high degree polynomial curve," In Proceedings of the 2022 4th International Conference on Robotics, Intelligent Control and Artificial Intelligence, pp. 87-94, 2022.
P. Ramdya et al., "Climbing favours the tripod gait over alternative faster insect gaits," Nature communications, vol. 8, no. 1, p. 14494, 2017.
T. G. Thuruthel, E. Falotico, M. Manti, and C. Laschi, "Stable Open Loop Control of Soft Robotic Manipulators," in IEEE Robotics and Automation Letters, vol. 3, no. 2, pp. 1292-1298, April 2018, doi: 10.1109/LRA.2018.2797241.
Y. Ding, A. Pandala, C. Li, Y. -H. Shin, and H. -W. Park, "Representation-Free Model Predictive Control for Dynamic Motions in Quadrupeds," in IEEE Transactions on Robotics, vol. 37, no. 4, pp. 1154-1171, Aug. 2021, doi: 10.1109/TRO.2020.3046415.
G. Xin, W. Wolfslag, H.-C. Lin, C. Tiseo, and M. Mistry, "An optimization-based locomotion controller for quadruped robots leveraging cartesian impedance control," Frontiers in Robotics and AI, vol. 7, p. 48, 2020.
G. Picardi, M. Chellapurath, S. Iacoponi, S. Stefanni, C. Laschi, and M. Calisti, "Bioinspired underwater legged robot for seabed exploration with low environmental disturbance," Science Robotics, vol. 5, no. 42, 2020.
Y. Chen, N. Doshi, and R. J. Wood, "Inverted and Inclined Climbing Using Capillary Adhesion in a Quadrupedal Insect-Scale Robot," in IEEE Robotics and Automation Letters, vol. 5, no. 3, pp. 4820-4827, July 2020, doi: 10.1109/LRA.2020.3003870.
X. Meng, S. Wang, Z. Cao, and L. Zhang, "A review of quadruped robots and environment perception," 2016 35th Chinese Control Conference (CCC), pp. 6350-6356, 2016, doi: 10.1109/ChiCC.2016.7554355.
M. Buehler, "Dynamic locomotion with one, four and six-legged robots," Journal of the Robotics Society of Japan, vol. 20, no. 3, pp. 237-242, 2002.
J. Z. Gul, B.-S. Yang, Y. J. Yang, D. E. Chang, and K. H. Choi, "In situ UV curable 3D printing of multi-material tri-legged soft bot with spider mimicked multi-step forward dynamic gait," Smart Materials and Structures, vol. 25, no. 11, p. 115009, 2016.
H. Li and P. M. Wensing, "Hybrid Systems Differential Dynamic Programming for Whole-Body Motion Planning of Legged Robots," in IEEE Robotics and Automation Letters, vol. 5, no. 4, pp. 5448-5455, Oct. 2020, doi: 10.1109/LRA.2020.3007475.
C. Mastalli, I. Havoutis, M. Focchi, D. G. Caldwell, and C. Semini, "Motion Planning for Quadrupedal Locomotion: Coupled Planning, Terrain Mapping, and Whole-Body Control," in IEEE Transactions on Robotics, vol. 36, no. 6, pp. 1635-1648, Dec. 2020, doi: 10.1109/TRO.2020.3003464.
M. Chen, H. Chen, X. Wang, J. X. Yu, and Y. X. Zhang, "Design and control of a novel single leg structure of electrically driven quadruped robot," Mathematical Problems in Engineering, vol. 2020, no. 1, pp. 3943867, 2020.
C. Bal, "Neural coupled central pattern generator based smooth gait transition of a biomimetic hexapod robot," Neurocomputing, vol. 420, pp. 210-226, 2021.
M. Chen, Q. Li, S. Wang, K. Zhang, H. Chen, and Y. Zhang, “Single-leg structural design and foot trajectory planning for a novel bioinspired quadruped robot,” Complexity, vol. 2021, no. 1, pp. 1–17, Jan. 2021, doi: 10.1155/2021/6627043.
H. Xia, X. Zhang, and H. Zhang, "A new foot trajectory planning method for legged robots and its application in hexapod robots," Applied Sciences, vol. 11, no. 19, p. 9217, 2021.
Y. Shao, Y. Jin, X. Liu, W. He, H. Wang, and W. Yang, "Learning Free Gait Transition for Quadruped Robots Via Phase-Guided Controller," in IEEE Robotics and Automation Letters, vol. 7, no. 2, pp. 1230-1237, April 2022, doi: 10.1109/LRA.2021.3136645.
Y. K. Kim, W. Seol, and J. Park, "Biomimetic quadruped robot with a spinal joint and optimal spinal motion via reinforcement learning," Journal of Bionic Engineering, vol. 18, no. 6, pp. 1280-1290, 2021.
Y. Ding, A. Pandala, and H. -W. Park, "Real-time Model Predictive Control for Versatile Dynamic Motions in Quadrupedal Robots," 2019 International Conference on Robotics and Automation (ICRA), pp. 8484-8490, 2019, doi: 10.1109/ICRA.2019.8793669.
Y. Yin, F. Gao, Q. Sun, Y. Zhao, and Y. Xiao, “Smart Gait: A Gait Optimization Framework for Hexapod Robots,” Chinese Journal of Mechanical Engineering, vol. 37, no. 1, p. 15, 2024.
H. Sun, J. Yang, Y. Jia, and C. Wang, "Free Gait Generation of Quadruped Robots via Impulse-Based Feasibility Analysis," in IEEE/ASME Transactions on Mechatronics, vol. 29, no. 1, pp. 412-422, Feb. 2024, doi: 10.1109/TMECH.2023.3279523.
Z. Qiu, W. Wei, and X. Liu, “Adaptive gait generation for hexapod robots based on reinforcement learning and hierarchical framework,” in Actuators, vol. 12, no. 2, p. 75, 2023.
A. Majithia et al., “Design, motions, capabilities, and applications of quadruped robots: a comprehensive review,” Frontiers in Mechanical Engineering, vol. 10, p. 1448681, 2024.
J. Ding and Z. Gan, "Breaking Symmetries Leads to Diverse Quadrupedal Gaits," in IEEE Robotics and Automation Letters, vol. 9, no. 5, pp. 4782-4789, May 2024, doi: 10.1109/LRA.2024.3384908.
J. Coelho, B. Dias, G. Lopes, F. Ribeiro, and P. Flores, “Development and implementation of a new approach for posture control of a hexapod robot to walk in irregular terrains,” Robotica, vol. 42, no. 3, pp. 792-816, 2024.
C. Bal, “Neural coupled central pattern generator based smooth gait transition of a biomimetic hexapod robot,” Neurocomputing, vol. 420, pp. 210-226, 2021.
J. Ma, G. Qiu, W. Guo, P. Li, and G. Ma, “Design, analysis and experiments of hexapod robot with six-link legs for high dynamic locomotion,” Micromachines, vol. 13, no. 9, p. 1404, 2022.
N. Mingchinda, V. Jaiton, B. Leung, and P. Manoonpong, “Leg-body coordination strategies for obstacle avoidance and narrow space navigation of multi-segmented, legged robots,” Frontiers in Neurorobotics, vol. 17, p. 1214248, 2023.
B. Chong et al., “A general locomotion control framework for multi-legged locomotors,” Bioinspiration & Biomimetics, vol. 17, no. 4, p. 046015, 2022.
R. Ș. Dologa, H. Vălean, and A. Ianosi, "Design of a Stepping Hexapod Bio-Inspired Robot," 2024 IEEE International Conference on Automation, Quality and Testing, Robotics (AQTR), pp. 1-6, 2024, doi: 10.1109/AQTR61889.2024.10554226.
P. Manoonpong et al., “Insect-inspired robots: bridging biological and artificial systems,” Sensors, vol. 21, no. 22, p. 7609, 2021.
J. Cornejo et al., “Bio-inspired design of hard-bodied mobile robots based on arthropod morphologies: a 10-year systematic review and bibliometric analysis,” Bioinspiration & Biomimetics, 2024.
H. G. Meyer, D. Klimeck, J. Paskarbeit, U. Rückert, M. Egelhaaf, M. Porrmann, and A. Schneider, “Resource-efficient bio-inspired visual processing on the hexapod walking robot HECTOR,” Plos one, vol. 15, no. 4, p. e0230620, 2020.
Y. Liu, C. Wang, H. Zhang, and J. Zhao, “Research on the posture control method of hexapod robot for rugged terrain,” Applied Sciences, vol. 10, no. 19, p. 6725, 2020.
S. Erasmus. Guidance, control, and motion planning for a hexapod robot moving over uneven terrain, Doctoral dissertation, Stellenbosch: Stellenbosch University, 2023.
K. Xu, Y. Lu, L. Shi, J. Li, S. Wang, and T. Lei, “Whole-body stability control with high contact redundancy for wheel-legged hexapod robot driving over rough terrain,” Mechanism and machine theory, vol. 181, p. 105199, 2023.
E. A. Parra Ricaurte, J. Pareja, S. Dominguez, and C. Rossi, “Comparison of leg dynamic models for quadrupedal robots with compliant backbone,” Scientific Reports, vol. 12, no. 1, p. 14579, 2022.
Y. Liu, X. Fan, L. Ding, J. Wang, T. Liu, and H. Gao, “Fault-tolerant tripod gait planning and verification of a hexapod robot,” Applied Sciences, vol. 10, no. 8, p. 2959, 2020.
Downloads
Published
Issue
Section
License
Copyright (c) 2025 spoorthi singh, Mohammad Zuber, Naman Bhat, Rathina Kumar s, Ernnie Illyani Basri, Kamarul Arifin Ahmad, Manish Varun Yadav, Navya Thirumaleshwar Hegde
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Authors who publish with this journal agree to the following terms:
- Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgment of the work's authorship and initial publication in this journal.
- Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgment of its initial publication in this journal.
- Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).
This journal is based on the work at https://journal.umy.ac.id/index.php/jrc under license from Creative Commons Attribution-ShareAlike 4.0 International License. You are free to:
- Share – copy and redistribute the material in any medium or format.
- Adapt – remix, transform, and build upon the material for any purpose, even comercially.
The licensor cannot revoke these freedoms as long as you follow the license terms, which include the following:
- Attribution. You must give appropriate credit, provide a link to the license, and indicate if changes were made. You may do so in any reasonable manner, but not in any way that suggests the licensor endorses you or your use.
- ShareAlike. If you remix, transform, or build upon the material, you must distribute your contributions under the same license as the original.
- No additional restrictions. You may not apply legal terms or technological measures that legally restrict others from doing anything the license permits.
• Creative Commons Attribution-ShareAlike (CC BY-SA)
JRC is licensed under an International License
